"If the DEF level drops below 1.5 US gallons (5.5 l) The "first" warning message it is issued and a warning tone sounds.
#5 mph max service def system reset manual
For example, the manual states the following: There appears to be an inconsistency in the owner's manual. You will then only be able to drive a maximum 50 miles (80km) before the engine management restricts the number of starts remaining." If the check engine indicator lamp lights up, the exhaust gas after treatment is faulty or an emission related malfunction occurred (>page 211). When the number of remaining engine starts is zero and the engine is restarted the engine management prevents the vehicle from being driven at a speed exceeding 5 mph (8km/h). You should immediately add 2.0 US gallons (7.61) Of DEF(>page 147) or have the DEF supply reservoir filled at qualified specialist workshop. Subsequently, you will only be able to start the engine a further 16 times. After the first message, the DEF supply will last for approximately 1200 miles (1900km). If a reserve mark of 0.8 US gallons (3.0 l) is reached, a second warning message is issued and a warning tone sequence sounds. After the message appears for the first time, and under normal driving conditions, the remaining DEF supply will last approximately 1000 miles (1600km). If the DEF level drops below 1.5 US gallons (5.5 l) The first warning message it is issued and a warning tone sounds. After previous warning messages, the engine management then prevents a further engine start. The engine management recognizes attempts to operate the vehicle without DEF, with thinned DEF or with another reducing agent. To conform to emission regulations, you must operate the vehicle with DEF and refill the supply "regularly". Therefore, add to the DEF supply tank "regularly" during vehicle operation or, at the "latest", after receiving the first warning message via the on board computer. The DEF range is dependent on operating and driving conditions. "To function properly, exhaust gas after treatment must be operated with Diesel Exhaust Fluid (DEF) reducing agent. I referred to page 25 of my trusty 2015 sprinter owner's manual which, states the following: Just glad I wasn't further from home when this happened. What else?īTW - tired of getting stuck and stranded with this unreliable POS. so I can make those suggests to the repair tech.
#5 mph max service def system reset software
So I'm looking for suggestions for parts that need to be check/replaced - NOx sensors, ECU, software updates, etc. I'm worried the champions at my local dealer will simply reset the light and not property repair the emission system. Since I'm so close to the end of my warranty I need to make this service call effective and get whatever is wrong corrected properly because the next service will be off-warranty. I'll be hobbling it home tomorrow and will be dropping it off at the Kennewick, WA dealership for warranty service and I'll be at 35,300 miles. So there is something seriously wrong (seriously expensive $$) with the emission system. At the next stop I bought some DEF and when I filled the DEF tank it was only a gallon low, no where near being empty.
I didn’t get a DEF low warning light, just straight to the "10 starts remaining" light. Then I got a CEL for about 30 min and then directly to the “10 starts remaining” light. I was driving west on I-90 over Snoqualmie Pass heading for the pacific coast and the season opening of halibut fishing.